Saginaw Problems - Chevelle Tech
Chevelle Tech join team chevelle as a supporting member  
Chevelle Parts at SS396.com      
GROUND UP & SS396.com         
Official Sponsor of Team Chevelle
     

Auto Insurance

Chevelles.com is the premier Chevrolet Chevelle Forum on the internet. Registered Users do not see the above ads.
Transmission & Driveline Transmissions and Differentials

Reply
 
Thread Tools Search this Thread Display Modes
  #1  
Old Mar 31st, 10, 8:46 PM
MrBill66Malibu MrBill66Malibu is offline
Senior Tech Team
Bill
 
Join Date: Aug 2005
Location: King NC via Long Island NY
Posts: 3,783
Send a message via AIM to MrBill66Malibu
Default Saginaw Problems

My brother has the old Saginaw out of my Malibu in his 69 Caprice.

He does not hammer this car at all and he has driven it very gently as the 427 in front of it could reduce it to rubble very quickly.

He went to back it up today and heard a loud bang, after that the trans makes a clicking noise above 25 mph. It still has all it's gears working and shifts fine. Needless to say it is parked just as cruise season is beginning

Unfortunately money is very tight for him, I know most will say to get a Muncie, but he just cannot afford it at this time.

Any thoughts on what could have broke?
__________________
Bill
385
4 speed M20
3:42 posi
1/8 mile 8.6 @ 84mph not too impressive LOL
http://s71.photobucket.com/albums/i1...libu/Chevelle/
Reply With Quote Quick reply to this message
Sponsored Links
Advertisement
 
  #2  
Old Mar 31st, 10, 9:09 PM
Mike Mike is offline
Lifetime Premium Member
 
Join Date: Apr 2005
Location: North America
Posts: 14,555
Default Re: Saginaw Problems

Just pull it out and open the side cover to see just what's wrong as there's not much point in guessing.
Reply With Quote Quick reply to this message
  #3  
Old Mar 31st, 10, 9:32 PM
MEJ1990TM MEJ1990TM is offline
Senior Tech Team
Michael
 
Join Date: Feb 2007
Location: Escondido, California
Posts: 7,515
Send a message via AIM to MEJ1990TM
Default Re: Saginaw Problems

What Mike said. Pulling it doesn't take long at all. Put the front end up on ramps, rear end on jack stands, un bolt the drive shaft, slide shaft out, unbolt trans from bell housing and then slide it out. The trans will have to be in gear when you unbolt the caps that hold the drive shaft in place. Be sure whatever shifter handle you've got is taken off of the stick. Also, be sure to stick a yoke ,or seal, in the rear of the trans after you pull the drive shaft.
__________________
1966 Charger (383, 727 Torqueflight)
1970 SS 454 Chevelle (LS5+2, M22, 3.31 12 bolt)
1971 Malibu (350, M22, 3.31 12 Bolt)

I'm looking for a girl with a car, and a house..........with cable.

http://s160.photobucket.com/albums/t164/MEJ1990TM
Reply With Quote Quick reply to this message
  #4  
Old Apr 1st, 10, 6:46 PM
StupidSexyFlanders StupidSexyFlanders is offline
Tech Team
Jeff
 
Join Date: Feb 2010
Location: SE Ohio
Posts: 87
Default Re: Saginaw Problems

I've been running these saginaws since I was a kid, and have a few parts lying around.
The trans is probably the easiest one out there to tear down and reassemble. A good hammer, brass drift, snap-ring pliers and some wrenches is about all you need unless you have to press the synchronizers off the main shaft.
Once he finds out what's broke, PM me to see if I have anything he can use...little something to cover shipping is all I would need.
Reply With Quote Quick reply to this message
  #5  
Old Apr 1st, 10, 7:04 PM
MrBill66Malibu MrBill66Malibu is offline
Senior Tech Team
Bill
 
Join Date: Aug 2005
Location: King NC via Long Island NY
Posts: 3,783
Send a message via AIM to MrBill66Malibu
Default Re: Saginaw Problems

Jeff and everyone, I appreciate the advice and yes we will be removing it to see whats up with it!!

Jeff, I appreciate the offer and I will let you know if we need something.
__________________
Bill
385
4 speed M20
3:42 posi
1/8 mile 8.6 @ 84mph not too impressive LOL
http://s71.photobucket.com/albums/i1...libu/Chevelle/
Reply With Quote Quick reply to this message
Sponsored Links
Advertisement
 
Reply
Chevelle Tech > Mechanical > Transmission & Driveline      Current Topic: Saginaw Problems
Quick Reply
Message:
Options

Register Now

In order to be able to post messages on the Chevelle Tech forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.
User Name:
If you do not want to register, fill this field only and the name will be used as user name for your post.
Password
Please enter a password for your user account. Note that passwords are case-sensitive.
Password:
Confirm Password:
Email Address
Please enter a valid email address. Note, you will be sent a confirmation request to this address.
Email Address:

Log-in

Human Verification

In order to verify that you are a human and not a spam bot, please enter the answer into the following box below based on the instructions contained in the graphic.



Thread Tools Search this Thread
Search this Thread:

Advanced Search
Display Modes

Posting Rules
You may post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

Forum Jump


All times are GMT -4. The time now is 4:25 AM.


Is there a site like this for?    El Caminos Camaros Novas Impalas GTO Chevy Punch All Chevys

2009 Team Chevelle - AutoForums